Hotchkis 22412 04-07 Scion xA-xB Sport Sway Bars Manuel d'utilisateur télécharger pdf

22412 FRONT AND REAR SPORT STABILIZER BAR SET

Scion xA/xB

Thank you for your purchase from our Hotchkis line of suspension parts.

Please call us at (877) 4NO-ROLL if you have any questions regarding your Hotchkis products.

Visit us online @ www.hotchkis.net . PLEASE READ THE ENTIRE INSTRUCTION MANUAL

BEFORE BEGINNING THE INSTALLATION.

INSTALLATION OF HOTCHKIS FRONT STABILIZER BAR

1) Please look at the original front antiroll bar and note the orientation of the front bar. You

will want to install the new Hotchkis bar in the same manner. You will find the bar

mounted directly to the engine cradle, just behind the steering rack on the top of the

cradle. Look carefully how the hoses are routed around the bar, as you will need to

have them in the same spot when you are finished with the installation of the Hotchkis

bar.

2) Use a jack to raise the vehicle and support with jack stands. It is much easier if the

whole vehicle is in the air.

3) Remove the rear reinforcement bracket that hold the subframe to the frame rails of the

car. Use a 14mm socket to remove the bolts holding the brace. There are two of them

on the car.

4) Take out the bolts that hold the motor mount to the engine cradle. These are 14mm

bolts.

5) Start removing the bolts that hold the cradle to the body using 17mm sockets.

6) Remove the bolts that hold the steering rack to the cradle. These are 17mm. Please

note that there is a nut on the top side of the steering rack you have to get a wrench on.

1 2 3 4 5 6 7 8

Page 1

22412 FRONT AND REAR SPORT STABILIZER BAR SET Scion xA/xB Thank you for your purchase from our Hotchkis line of suspension parts. Please call

Page 2

7) Once these bolts are all out, the subframe should only be held on by the lower control arms. 8) Carefully pull down on the back part of the subf

Page 3

oriented. You want the split to face the rear of the car when the bar is installed in the. 15) Slip the new greasable bracket over top of the

Page 4

INSTALLATION OF HOTCHKIS REAR SWAY BAR 1) Securely block the front wheels of the vehicle. Jack up the vehicle and support it with jack stands. 2)

P/N 22412 2003 Scion xA/xB Stabilizer Bar Kit, Parts List Hotchkis P/N Item DescriptionQuantity per kit1 22820235 Front Sway Bar, 2003 Scion 12 22920

Hotchkis Performance LLC Return Policy & Limited Warranty Effective December 1, 2010 all Hotchkis products must be registered to qualify fo

Page 7

anyone, is for the sole purpose of identifying them and is not part of the basis of the bargain, and does not constitute a warranty that the products

Page 8

SANTA FE SPRINGS, CA 90670 Hotchkis Performance will not accept product returns without the RGA number, receipt and the information described above.

Pas de commentaire

Hotchkis 22412 04-07 Scion xA-xB Sport Sway Bars Manuel d'utilisateur